Juicy's Ribs, LLC

Observed a cook chewing gum while preparing food in the kitchen. PIC advised that you cannot chew gum during food preparation.

511-6-1.03(5)(k)1&2 - Eating, Drinking, or Using Tobacco (C) (k) Hygienic Practices.

1. Employees shall not use any form of tobacco products, or electronic devices that simulate tobacco smoking, while engaged in food preparation or service, nor while in areas used for equipment or utensil washing and storage, food preparation or food storage. Employees shall only use tobacco products or electronic devices that simulate tobacco smoking in approved designated areas.

2. Employees shall consume food only in approved designated areas separate from food preparation and serving areas, equipment or utensil areas and food storage areas. However, drinking from a single service beverage cup with a secure lid and straw that is handled to prevent contamination of the employee’s hands, the container, exposed food, clean equipment, utensils and linens, unwrapped single-service and single-use articles will be allowed.

Observed the cold water pressure was low on the handwashing sink.

511-6-1.06(2)(r) - System Maintained in Good Repair (P, C) (r) System Maintained in Good Repair. A plumbing system shall be repaired according to law; P and maintained in good repair.

Observed that an employee must wash hand sign must be installed or posted at all handwashing sinks.

511-6-1.07(3)(d) - Handwashing Signage (C) (d) Handwashing Signage. A sign or poster that notifies food employees to wash their hands shall be provided at all handwashing sinks used by food employees and shall be clearly visible to food employees.

Observed cracked lids on hotel pans used to cool and store ribs and chicken.

511-6-1.05(2)(c) - Multiuse Food-Contact Surfaces (Pf) (c) Multiuse Food-Contact Surfaces.

1. Multiuse food-contact surfaces shall be:

(i) Smooth; Pf

(ii) Free of breaks, open seams, cracks, chips, inclusions, pits, and similar imperfections; Pf

(iii) Free of sharp internal angles, corners, and crevices; Pf

(iv) Finished to have smooth welds and joints; Pf and

(v) Except as specified in paragraph 2 of this subsection, accessible for cleaning and inspection by one of the following methods:

(I) Without being disassembled, Pf

(II) By disassembling without the use of tools, Pf or

(III) By easy disassembling with the use of handheld tools commonly available to maintenance and cleaning personnel such as screwdrivers, pliers, open-end wrenches, and Allen wrenches. Pf

2. The requirement in paragraph 1(v) of this subsection does not apply to cooking oil storage tanks, Distribution lines for cooking oils, or beverage syrup lines or tubes.

Observed build up on shelves. PIC advised to deep clean shelves by 6/13/26.

511-6-1.05(7)(a)2,3 - Equipment, Food/Nonfood-Contact Surfaces, and Utensils, food-contact surfaces of cooking equipment & nonfood-contact surfaces free of accumulations (C) 2. The food-contact surfaces of cooking equipment and pans shall be kept free of encrusted grease deposits and other soil accumulations.

3. Nonfood-contact surfaces of equipment shall be kept free of an accumulation of dust, dirt, food residue, and other debris.

Observe the certified food safety manager certificate is expired. The certificate expired on 01/06/2025. PIC will review the certificate by 03/06/2025. 511-6-1.03(3)(a) - Food Safety Manager Certification (Pf) Food service establishments shall have in its employ a Certified Food Safety Manager (CFSM) as specified in paragraph (b) of this subsection to ensure food safety is being managed within the food service establishment during all hours of operation as specified within paragraph (d) of this subsection. Pf

Observed the chlorine sanitizing solution at a concentration above 50-100 ppm in the three compartment sink. PIC corrected on site by remaking the sanitizer to a concentration of 100 ppm.

Observed build up on shelves above the dish storage area. PIC advised to deep clean the area on a weekly basis to prevent build up.

Observed the prep sinks cannot dispose of the waste water properly. PIC will contact maintenance and have the plumbing lines repaired. Hub drain was observed draining slowly. PIC will email a copy of the service work order by 6/15/25 to Robert.lewis1@dph.ga.gov

Observed build-up of food debris, dust or dirt on nonfood-contact surface. PVC pipes observed with build up below the three-compartment sink. PIC will clean the area by 06/08/25. PIC will also deep clean once a week.

Observed build up on walls in the three compartment sink area. PIC will clean walls on a weekly basis to prevent build up.

Violation Code Reference 511-6-1.07(5)(a),(b) - Good Repair, physical facilities maintained; Cleaning, Frequency & Restrictions, cleaned often enough to keep them clean (C) (5) Maintenance and Operation.

(a) Good Repair. All physical facilities shall be maintained in good repair.

(b) Cleaning, Frequency and Restrictions.

1. The physical facilities shall be cleaned as often as necessary to keep them clean and by methods that prevent contamination of food products.

2. Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of food is exposed, such as after closing.

Observed cooked collard greens and chicken observed in the walk in cooler not properly date marked. PIC corrected on site by adding date labels. Product was prepared on 12/12/24. Prepared food not marked with date of preparation or date for disposal.

511-6-1.04(6)(g) - Ready-To-Eat Time/Temperature Control for Safety Food, Date Marking (Pf) (g) Ready-to-Eat Time/Temperature Control for Safety Food, Date Marking

1. Except when packaging food using a reduced oxygen packaging method, and except as specified in paragraphs 4 and 5 of this subsection, refrigerated, ready-to-eat, time/temperature control for safety food prepared and held in a food establishment for more than 24 hours shall be clearly marked to indicate the date or day by which the food shall be consumed on the premises, sold, or discarded, when held at a temperature of 41°F (5°C) or below for a maximum of 7 days. The day of preparation shall be counted as Day 1. Pf

2. Except as specified in paragraphs 4 through 6 of this subsection, refrigerated, ready-to-eat, time/temperature control for safety food prepared and packaged by a food processing plant shall be clearly marked, at the time the original container is opened in a food service establishment and if the food is held for more than 24 hours, to indicate the date or day by which the food shall be consumed on the premises, sold, or discarded, when held at a temperature of 41°F (5°C) or below for a maximum of 7 days after the original container is opened. The day the original container is opened in the food service establishment shall be counted as Day 1, except, the day or date marked by the food service establishment may not exceed a manufacturer’s use by date if the manufacturer determined the use-by date based on food safety; Pf

Observed build-up of food debris, dust or dirt on nonfood-contact surface. PVC pipes observed with build up below the three-compartment sink. PIC will clean the area by 12/26/2024. PIC will also deep clean once a week.

511-6-1.05(7)(a)2,3 - Equipment, Food/Nonfood-Contact Surfaces, and Utensils, food-contact surfaces of cooking equipment & nonfood-contact surfaces free of accumulations (C) 2. The food-contact surfaces of cooking equipment and pans shall be kept free of encrusted grease deposits and other soil accumulations.

3. Nonfood-contact surfaces of equipment shall be kept free of an accumulation of dust, dirt, food residue, and other debris.

Collard Greens observed in the walk in cooler not properly date marked.

Observed the hot water in the restroom hand sink did not reach 11 degrees F

Non food contact surface storage areas contained build up

Observed ribs at a temperature of 53 degrees in the reach in cooler. PIC reheated to 165 for 15 seconds.

Shelves used to store seasonings contained build up