GOLDEN CORRAL BUFFET & GRILL

Observed dish washing machine with a final sanitizing temperature of 154F and a wash cycle temperature of 160F 511-6-1.05(6)(l) - Mechanical Warewashing, Hot Water Sanitization Temperatures(P) (l) Mechanical Warewashing Equipment, Hot Water Sanitization Temperatures.

1. Except as specified in paragraph 2 of this subsection, in a mechanical operation, the temperature of the fresh hot water sanitizing rinse as it enters the manifold may not be more than 194ºF (90ºC), or less than: Pf

(i) For a stationary rack, single temperature machine, 165ºF (74ºC); Pf or

(ii) For all other machines, 180ºF (82ºC). Pf

2. The maximum temperatures specified under paragraph 1 of this subsection, do not apply to the high pressure and temperature systems with wand-type, hand-held, spraying devices used for the in-place cleaning and sanitizing of equipment such as meat saws. Dish Machine final sanitizing temperature can not exceed 194 Degrees Fahrenheit.

Note: The Manager will call Ecolab to come to repair the dish washing machine. Faacility will use the (3) Compartment sink to wash rinse and sanitize all equipment.

Cut lettuce was observed cooling in the walk in cooler covered with a Lid. 511-6-1.04(6)(e) - Cooling Methods (Pf, C) (e) Cooling Methods.

1. Cooling shall be accomplished in accordance with the time and temperature criteria specified under DPH Rule 511-6-1-.04(6)(d) by using one or more of the following methods depending on the type of food being cooled:

(i) Placing the food in shallow pans; Pf

(ii) Separating the food into smaller or thinner portions; Pf

(iii) Using rapid cooling equipment; Pf

(iv) Stirring the food in a container placed in an ice water bath; Pf

(v) Using containers that facilitate heat transfer; Pf. Note: Lettuce was uncovered during the inspection.

Observed dish washing machine with a final sanitizing temperature of 180F and a wash cycle temperature of 140F 511-6-1.05(6)(l) - Mechanical Warewashing, Hot Water Sanitization Temperatures(P) (l) Mechanical Warewashing Equipment, Hot Water Sanitization Temperatures.

1. Except as specified in paragraph 2 of this subsection, in a mechanical operation, the temperature of the fresh hot water sanitizing rinse as it enters the manifold may not be more than 194ºF (90ºC), or less than: Pf

(i) For a stationary rack, single temperature machine, 165ºF (74ºC); Pf or

(ii) For all other machines, 180ºF (82ºC). Pf

2. The maximum temperatures specified under paragraph 1 of this subsection, do not apply to the high pressure and temperature systems with wand-type, hand-held, spraying devices used for the in-place cleaning and sanitizing of equipment such as meat saws. Dish Machine final sanitizing temperature can not exceed 194 Degrees Fahrenheit.

Note: The Manager will call Ecolab to come to repair the dish washing machine. Faacility will use the (3) Compartment sink to wash rinse and sanitize all equipment.

Single service plates were observe stored uncovered in the dry storage area of the facility.
511-6-1.05(10)(e)1&3 - Single-Service/Single-Use items stored 6" off floor in clean, dry location (C) (e) Equipment, Utensils, Linens, and Single-Service and Single-Use Articles.

1. Except as specified in paragraph 4 of this subsection, cleaned equipment and utensils, laundered linens, and single-service and single-use articles shall be stored:

(i) In a clean, dry location;

(ii) Where they are not exposed to splash, dust, or other contamination; Note: Single service items were immediately covered during the inspection.

Ground beef was observed hot holding in a warmer cabinet at 119 Degrees Fahrenheit.
511-6-1.04(6)(f) - Time/Temperature Control for Safety; Hot Holding (P) (f) Time/Temperature Control for Safety Food, Hot and Cold Holding. Except during preparation, cooking, or cooling, or when time is used as the public health control, time/temperature control for safety food shall be maintained at 41°F (5°C) or below or 135°F (57°C) or above, except that roasts cooked to a temperature and for a time specified in subsection (5)(a)2 of this Rule and reheated using the same temperature and time conditions as cooking may be held at a temperature of 130°F (54°C) or above. P. Note: Ground Beef was voluntarily discarded during the inspection.

Observed dish washing machine with a final sanitizing temperature of 200F 511-6-1.05(6)(l) - Mechanical Warewashing, Hot Water Sanitization Temperatures(P) (l) Mechanical Warewashing Equipment, Hot Water Sanitization Temperatures.

1. Except as specified in paragraph 2 of this subsection, in a mechanical operation, the temperature of the fresh hot water sanitizing rinse as it enters the manifold may not be more than 194ºF (90ºC), or less than: Pf

(i) For a stationary rack, single temperature machine, 165ºF (74ºC); Pf or

(ii) For all other machines, 180ºF (82ºC). Pf

2. The maximum temperatures specified under paragraph 1 of this subsection, do not apply to the high pressure and temperature systems with wand-type, hand-held, spraying devices used for the in-place cleaning and sanitizing of equipment such as meat saws. Dish Machine final sanitizing temperature can not exceed 194 Degrees Fahrenheit.